5W DC-DC Regulated Single Output
■
Features :
Wide 4:1 DC input range
NSD05-S
Protections: Short circuit / Overload / Over voltage
1000VDC I/O isolation
Cooling by free air convection
Built-in remote ON-OFF control
100% full load burn-in test
Low cost
High reliability
2 years warranty
series
SPECIFICATION
MODEL
DC VOLTAGE
RATED CURRENT
CURRENT RANGE
RATED POWER
OUTPUT
CAPACITIVE LOAD (max.)
NSD05-12S3
3.3V
1.2A
0 ~ 1.2A
3.96W
1000uF
NSD05-12S5
5V
1A
0 ~ 1A
5W
1000uF
NSD05-12S12 NSD05-12S15 NSD05-48S3
12V
0.42A
0 ~ 0.42A
5.04W
120uF
15V
0.33A
0 ~ 0.33A
4.95W
120uF
3.3V
1.2A
0 ~ 1.2A
3.96W
1000uF
NSD05-48S5
5V
1A
0 ~ 1A
5W
1000uF
NSD05-48S12 NSD05-48S15
12V
0.42A
0 ~ 0.42A
5.04W
120uF
15V
0.33A
0 ~ 0.33A
4.95W
120uF
RIPPLE & NOISE (max.)
Note.2
75mVp-p
VOLTAGE TOLERANCE
Note.3
±2.0%
max.
LINE REGULATION
LOAD REGULATION
SETUP TIME
RATED DC INPUT
VOLTAGE RANGE
EFFICIENCY (Typ.)
DC CURRENT
SHUTDOWN IDLE CURRENT
OVERLOAD
PROTECTION
FUNCTION
OVER VOLTAGE(CLAMP)
SHORT CIRCUIT
ON/OFF CONTROL
WORKING TEMP.
WORKING HUMIDITY
STORAGE TEMP., HUMIDITY
±1.0%
±2.0%
±1.0%
±1.0%
±1.0%
±2.0%
48VDC
18 ~ 72VDC
75%
0.2A/48VDC
5mA/48VDC
±1.0%
±1.0%
±1.0%
80ms
/
RATED DC INPUT at full Load
12VDC
9.2 ~ 36VDC
72%
76%
82%
0.7A/12VDC
5mA/12VDC
INPUT
83%
78%
83%
85%
Above 105% rated output power
Protection type : Over power limiting, recovers automatically after fault condition is removed
3.8 ~ 4.6V
5.6 ~ 6.8V
13.5 ~ 16.5V 16.2 ~ 19.8V 3.8 ~ 4.6V
5.6 ~ 6.8V
Recovers automatically after fault condition is removed
Logic "1" or open circuit : ON
Logic "0" or short to PIN2 : OFF
-25 ~ +70℃
0% ~ 95% RH max.
-40 ~ +85
℃
, 0 ~ 95% RH
±
0.03%/
℃
(0~60
℃)
IEC60950-1 CB approved by TUV,
EAC TP TC 004
approved
I/P-O/P:1KVDC
I/P-O/P:100M Ohms / 500VDC / 25
℃
/ 70% RH
Compliance to EN55032 (CISPR32) Class B, EAC TP TC 020
13.5 ~ 16.5V
16.2 ~ 19.8V
ENVIRONMENT
TEMP. COEFFICIENT
SAFETY STANDARDS
SAFETY & ISOLATION VOLTAGE
ISOLATION RESISTANCE
EMC
(Note 4)
EMC EMISSION
EMC IMMUNITY
MTBF
OTHERS
NOTE
Compliance to EN61000-4-2,3,4,5,6,8; EN55024, light industry level, criteria A, EAC TP TC 020
914.4K hrs min. MIL-HDBK-217F (25
℃
)
40.6*25.4*8.3mm (1.6"*1"*0.327") (L*W*H)
0.007Kg; 700pcs/5.9Kg/0.97CUFT
DIMENSION
PACKING
1. All parameters NOT specially mentioned are measured at 12, 48VDC input, rated load and 25
℃
of ambient temperature.
2. Ripple & noise are measured at 20MHz of bandwidth by using a 12" twisted pair-wire terminated with a 0.1uf & 47uf parallel capacitor.
3. Tolerance : includes set up tolerance, line regulation and load regulation.
4. The power supply is considered a component which will be installed into a final equipment. All the EMC tests are been executed by mounting the unit on
a 230mm*230mm metal plate with 1mm of thickness. The final equipment must be re-confirmed that it still meets EMC directives. For guidance on how to
perform these EMC tests, please refer to EMI testing of component power supplies. (as available on http://www.meanwell.com)
5. To insure proper operation, a 47uF/100V electrolytic capacitor with Esr <1
Ω
must be added to the input line.
6.EMC filter suggestion(TBD):
5.5uH
+
Vin
-
680uF
+
+
PSU
Vo
-
7. The ambient temperature derating of 3.5
℃
/1000m with fanless models and of 5
℃
/1000m with fan models for operating altitude higher than 2000m(6500ft).
File Name:NSD05-S-SPEC 2018-01-12
5W DC-DC Regulated Single Output
Mechanical Specification
40.6 [1.6]
30.48 [1.2]
10.16 [0.4]
NSD05-S
series
Unit:mm[inch]
10.16[0.4]
2.54[0.1]
5
15.24[0.6]
2.54[0.1]
6 [0.236]
4
25.4[1]
2
1
3
1.5[0.059]
0.64mm square pins
Pin No. Assignment
Pin No.
1
2
3
Assignment
+INPUT
-INPUT(GND)
+VOUT
Pin No.
4
5
Assignment
-VOUT
CONTROL
Block Diagram
POWER
SWITCHING
RECTIFIERS
&
FILTER
8.3 [0.327]
3 [0.118]
22.86[0.9]
fosc : 350KHz
+VOUT
-VOUT
I/P
O.L.P.
C
TRL
PWM
CONTROL
DETECTION
CIRCUIT
O.V.P.
Derating Curve
ON/OFF Control
1
+VIN
+VOUT
3
100
2
80
75
60
-VIN
LOAD
5
4
C
TRL
-VOUT
LOAD (%)
40
CONTROL INPUT.....................................PIN5
20
CONTROL COMMON................................PIN2
LOGIC COMPATIBILITY......CMOS OR OPEN COLLECTOR TTL
-25 -10
0
10
20
30
40
50
60
70 (HORIZONTAL)
CONTROL VOLTAGE
ON............+5.5VDC min OR OPEN CIRCUIT
OFF......+2.5VDC max. OR SHORT TO PIN2
AMBIENT TEMPERATURE (
℃
)
File Name:NSD05-S-SPEC 2018-01-12
RF/Wirelessly
京公网安备 11010802033920号
EEWORLD
