characterized with very high capacitance in a small volume.
By vertical stacking of the ceramic elements, the footprint
required for mounting the capacitors is greatly reduced.
TurboCaps
TM
are ideally suited as filters in the input and
output stages of switch mode power supplies (SMPS). With
their ultra-low ESR, these capacitors are designed to handle
high ripple current at high frequencies and high power levels.
The DIP leads in either thru-hole or surface mount
configurations offer superior stress relief to the ceramic
elements. The leads effectively decouple the parts from the
board and minimize thermally or mechanically induced
stresses encountered during assembly, temperature cycling
or other environmental conditions.
TYPICAL APPLICATION OF TURBOCAP
TM
SMPS CAPACITORS FOR INPUT
AND OUTPUT FILTERS IN DC/DC CONVERTERS
SNUBBER
Vin
OUTPUT
FILTER
Vout
INPUT
FILTER
VCC
G
FB
PWM
CONTROLLER
GND
Performance of SMPS capacitors can be simulated by downloading SpiCalci software program -
http://www.avx.com/SpiApps/default.asp#spicalci
Custom values, ratings and configurations are also available.
MAY 2015
■
49
TurboCap
TM
High-CV SMPS Capacitors
ELECTRICAL SPECIFICATIONS
Temperature Coefficient
Temperature Coefficient
±15%, -55° to +125°C
Dielectric Withstanding Voltage 25°C
(Flash Test)
250% rated voltage for 5 seconds with 50 mA max charging current.
Life Test
(1000 hrs)
X7R: 150% rated voltage at +125°C.
Moisture Resistance
(MIL-STD-202 Method 106)
Ten cycles with no voltage applied.
Thermal Shock
(MIL-STD-202 Method 107, Condition A)
Immersion Cycling
(MIL-STD-202 Method 104, Condition B)
Resistance To Solder Heat
(MIL-STD-202, Method 210,
Condition B, for 20 seconds)
Capacitance Test
(MIL-STD-202 Method 305)
25°C, 1.0±0.2 Vrms (open circuit voltage) at 1KHz
Dissipation Factor 25°C
2.5% Max @ 25°C, 1.0±0.2 Vrms (open circuit voltage) at 1KHz
Insulation Resistance 25°C
(MIL-STD-202 Method 302)
500 MΩ-μF, whichever is less.
Insulation Resistance 125°C
(MIL-STD-202 Method 302)
50 MΩ-μF, whichever is less.
Typical ESR Performance (Ω)
ESR @ 10KHz
ESR @ 50KHz
ESR @ 100KHz
27μF
0.007
0.003
0.002
47μF
0.004
0.002
0.0015
100μF
0.003
0.0015
0.001
Not RoHS Compliant
HOW TO ORDER
ST12
AVX
Style
ST12
ST20
AVX Styles: ST12 and ST20
C
186
Capacitance Code
(2 significant digits
+ no. of zeros)
1 μF = 105
10 μF = 106
100 μF = 107
5
Voltage
25V = 3
50V = 5
100V = 1
M
Capacitance
Tolerance
M = ±20%
A
Test Level
A = Standard
N
Termination
N = Straight Lead
J = Leads formed in
L = Leads formed out
03
Number
of Leads
Per Side
03 = 3
05 = 5
10 = 10
Temperature
Coefficient
X7R = C
CAPACITANCE (μF)
ST12
Cap (μF)
.82
1.3
2.7
8.2
12
14
18
22
27
47
50
68
100
220
50V
100V
Voltage
25V
ST20
50V
100V
...03
...05
...03
...03
...10
...05
...10
...03
...05
...10
...10
...03
...05
...05
...10
50
■
MAY 2015
TurboCap
TM
High-CV SMPS Capacitors
E
D
B
A
1.397 (0.055)
±0.254
(0.010)
6.35 (0.25)
MIN.
0.508 (0.020) TYP.
3, 5 or 10 leads per side
2.54 (0.100) TYP.
2.54 (0.100) MAX.
0.635 (0.025) MIN.
C
0.254 (0.010) TYP.
“N” STYLE LEADS
E
D
0.254 (0.010) RAD. TYP.
B
A
1.397 (0.055)
±0.254
(0.010)
1.778 (0.070)
± 0.254 (0.010)
B
0.508 (0.020) TYP.
3, 5 or 10 leads per side
2.54 (0.100) TYP.
2.54 (0.100) MAX.
0.635 (0.025) MIN.
C
1.397 (0.055)
± 0.127 (0.005)
“J” STYLE LEADS
E
D
B
A
1.397 (0.055)
±0.254
(0.010)
1.778 (0.070)
± 0.254 (0.010)
B
0.254 (0.010) RAD. TYP.
0.508 (0.020) TYP.
3, 5 or 10 leads per side
2.54 (0.100) TYP.
2.54 (0.100) MAX.
0.635 (0.025) MIN.
C
1.397 (0.055)
± 0.127 (0.005)
“L” STYLE LEADS
DIMENSIONS
Style
ST125C***M*N03
ST125C***M*N05
ST125C***M*N10
ST205C***M*N03
ST205C***M*N05
ST205C***M*N10
A (max.)
3.56
3.56
3.56
5.59
5.59
5.59
(0.140)
(0.140)
(0.140)
(0.220)
(0.220)
(0.220)
B (max.)*
5.21
5.21
5.21
7.24
7.24
7.24
(0.205)
(0.205)
(0.205)
(0.285)
(0.285)
(0.285)
C
± 0.635 (± 0.025)
5.08 (0.200)
5.08 (0.200)
5.08 (0.200)
6.35 (0.250)
6.35 (0.250)
6.35 (0.250)
D (max.)
10.8 (0.425)
15.9 (0.625)
27.9 (1.100)
9.5(0.375)
14.6 (0.575)
27.3 (1.075)
E (max.)
6.35
6.35
6.35
7.62
7.62
7.62
(0.250)
(0.250)
(0.250)
(0.300)
(0.300)
(0.300)
millimeters (inches)
Lead
Style
N
N
N
N
N
N
No. of Leads
Per Side
03
05
10
03
05
10
*The “B” dimension is defined for the “N” Style leads. The “L” and “J” Style Leads are 0.381 (0.015) longer. The ST12 will be 5.89 (0.220), the ST20 will be 7.62 (0.300).
summary
This blog gives a power supply solution for the heating unit, which mainly includes a lithium battery, a boost circuit (TPS61022) and a heating resistor (2 Ω). This solution supports a maximum...
At first, I was nervous about ADI's Audio Preamplifiers: SSM2019BNZ, SSM2019BRNZ, SSM2019BRWZ. Later, I heard that TI's INA217AIP, INA217AIDWR, INA163UA were also nervous? Are preamplifiers so hard to...
Live Topic: New Energy Lithium Battery Management Solution with Impedance Detection FunctionContent introduction:This seminar will introduce you to Datang NXP's battery management solution based on a ...
Normal delay
This delay method should be the earliest delay function that everyone comes into contact with when using the 51 MCU. This is relatively simple, allowing the MCU to do some insignificant w...
[i=s]This post was last edited by qwqwqw2088 on 2018-11-8 10:13[/i] [size=4] Let's first talk about what is electrostatic discharge (ESD)? This should be the main culprit for excessive electrical stre...
Some of the examples in the examples directory of ESP-Skainet also have audio playback - you can hear the sound by connecting the speaker directly or connecting the active speaker from the 3.5mm audio...
Radar level meter is a measuring instrument based on the time-travel principle. Radar waves run at the speed of light, and the running time can be converted into a level signal through electronic com...[Details]
1 Introduction Power transformers are widely used and very important electrical equipment in power systems. They are relatively reliable and have a low probability of failure. However, during operat...[Details]
With the rapid development of science and technology, photovoltaic power generation technology has been widely used both at home and abroad. Its application forms are diverse and the application place...[Details]
The Shanghai Auto Show is about to open, and it is said that Honeycomb Energy will make big moves!
According to reports, SVOLT will bring a full range of products to the show, with a lot to wa...[Details]
The OFweek Cup 2023 China Robot Industry Annual Awards (abbreviated as OFweek Robot Awards 2023) is jointly organized by OFweek, China's high-tech industry portal, and its authoritative
robot
...[Details]
Recently, the "Belt and Road" International Cooperation Summit Forum will be held in Beijing. Since the initiative was first proposed in 2013, the "Belt and Road" construction has grown from nothing ...[Details]
In our daily life, transformers are an indispensable electrical device. They can be as small as our mobile phone chargers that need to reduce the voltage to charge normally, as large as the step-up...[Details]
According to people familiar with the matter, U.S. Treasury Secretary Steven Mnuchin recently called on Huawei's U.S. suppliers to apply for exemption licenses to resume sales to Huawei. Market analy...[Details]
To meet the linearity and spectrum requirements of the air interface, the input signal level to the power amplifier is reduced so that it operates in the linear portion of the transfer curve, but this...[Details]
Renesas Electronics Corporation (TSE: 6723), a premier supplier of advanced semiconductor solutions, today announced the RX72M Industrial Network Solution to accelerate the development of industrial ...[Details]
introduction
In order to ensure that the solar power generation system can work normally, it is necessary to measure the various environmental parameters of the solar power generation system s...[Details]
Following the Amazon Echo smart speaker, accessory manufacturer Anker subsequently launched the Eufy Genie smart speaker, which also has a built-in Alexa voice assistant cloud platform. It only uses ...[Details]
Precision is generally expressed as accuracy, which reflects the size of the basic error of the instrument. The higher the accuracy, the smaller the measurement error. The accuracy of the multimeter ...[Details]
The simulation schematic diagram of the intelligent frequency meter is as follows The microcontroller source program is as follows: #ifndef main_c //test ok #define main_c #endif #include "mai...[Details]
How to deal with the phenomenon of wind and solar power abandonment? How to solve the safety problem of energy storage facilities? On October 29, the green and low-carbon technology project promotion ...[Details]
TI Technology Forum
京公网安备 11010802033920号
EEWORLD
