Product data sheet
Industrial CFast
TM
Card
F-240 Series
SATA II, UDMA6, TRIM, low power
Standard and industrial
temperature grade
B U:
Sw i ss b it Gr ou p
Date :
Ju l y 0 4, 20 1 3
Re vi si o n:
1 . 21
F - 24 0_ da ta_ s he e t_ C A - H x B V_Re v 1 2 1. do c
F-240 Series – Industrial CFast
TM
Card with SATA interface
1 Features
Highly-integrated memory controller
o
SATA Rev 2.6 - 3Gbit/s (1.5Gbit/s compatible)
o
max. UDMA6 MDMA2, PIO4, supported
o
Hardware BCH-code ECC
(24bit correction per double sector or
6bit per sector)
o
Fix drive configuration
Small form factor:
o
CompactFlash card sized Solid State Drive (SSD)
with SATA interface
o
42.8mm x 36.4mm x 3.3mm (max. 3.6mm)
7+17 pin (SATA+power) CFast connector
3.3V ± 5% power supply
Very low Power, typical 250mA in transfer operation (CFAST Power level 0)
CFast PHYSLP supported (<20 mA)
Activity and SATAlink LED output at LED1 and LED2 pin
write protect at connector IO1 pin
Special features
o
S.M.A.R.T. support with additional vendor information,
interpretation with Swissbit life time monitoring tool
o
TRIM command
o
NCQ queue depth 32
o
HPA (Host protected area)
o
Security mode feature set
o
LBA48 command set
o
host initiated power management requests
o
write protection with vendor command
Wear Leveling: active wear leveling of static and dynamic data
The wear leveling assures that dynamic data as well as static data is balanced evenly across the
memory. With that the maximum write endurance of the device is guaranteed.
Read disturb management (refresh data when flash often read)
High reliability
o
Best available SLC NAND Flash technology
o
Designed for embedded market
o
MTBF > 2,500,000 hours
o
Data reliability: < 1 non-recoverable error per 10
14
bits read
o
Number of connector insertions/removals: >10,000
High performance
o
Up to 300MB/s burst transfer rate in SATA II - 3.0Gb/sec
o
Sustained Write performance: up to 120MB/s
(4channel)
o
Sustained Read Performance: up to 120MB/s
(4channel)
Available densities
o
2GByte up to 64GByte (SLC NAND Flash)
2 Temperature ranges
o
Commercial Temperature range
0 … +70°C
o
Industrial Temperature range
-40 … +85°C
Life Cycle Management
Controlled BOM
RoHS compatible
Swissbit AG
Industriestrasse 4
CH-9552 Bronschhofen
Switzerland
Swissbit reserves the right to change products or specifications without notice.
www.swissbit.com
industrial@swissbit.com
Revision: 1.21
F-240_data_sheet_CA-HxBV_Rev121.doc
Page 2 of 60
2 Table of Content
1 FEATURES
...................................................................................................................................................................................2
2 TABLE OF CONTENT
....................................................................................................................................................................3
3 ORDER INFORMATION
...............................................................................................................................................................5
3.1 A
VAILABLE
S
TANDARD PART NUMBERS
......................................................................................................................................5
3.2 O
FFERED
OEM
OPTIONS
........................................................................................................................................................5
4 PRODUCT SPECIFICATION
...........................................................................................................................................................6
4.1 P
HYSICAL DESCRIPTION
..........................................................................................................................................................6
4.2 S
YSTEM
P
ERFORMANCE
.........................................................................................................................................................7
4.3 E
NVIRONMENTAL
S
PECIFICATIONS
............................................................................................................................................8
4.4 P
HYSICAL
D
IMENSIONS
.........................................................................................................................................................8
4.5 R
ELIABILITY
........................................................................................................................................................................8
4.6 D
RIVE GEOMETRY
/ CHS
PARAMETER
.......................................................................................................................................8
5 ELECTRICAL INTERFACE
..............................................................................................................................................................9
5.1 E
LECTRICAL DESCRIPTION
........................................................................................................................................................9
5.2 E
LECTRICAL
S
PECIFICATION
................................................................................................................................................... 10
5.3 LED
AND
IO-
PINS
............................................................................................................................................................. 10
5.4 C
ARD DETECTION AND
PHYSLP
FUNCTIONS WITH
CDI
AND
CDO
PIN
............................................................................................ 11
5.5 P
OWER
M
ANAGEMENT
........................................................................................................................................................ 13
6 ATA COMMAND DESCRIPTION..................................................................................................................................................
14
6.1 C
HECK
P
OWER
M
ODE
(98
H OR
E5
H
)
.................................................................................................................................... 16
6.2 D
ATA
S
ET
M
ANAGEMENT
(06
H
) TRIM
.................................................................................................................................. 16
6.3 E
XECUTE
D
RIVE
D
IAGNOSTIC
(90
H
)
....................................................................................................................................... 16
6.4 F
LUSH
C
ACHE
(E7
H
)
........................................................................................................................................................... 17
6.5 F
LUSH
C
ACHE
E
XT
(EA
H
) 48
BIT
LBA
.................................................................................................................................... 17
6.6 F
ORMAT TRACK
(50
H
)
........................................................................................................................................................ 17
6.7 I
DENTIFY
D
EVICE
(EC
H
)
....................................................................................................................................................... 18
6.8 I
DLE
(97
H OR
E3
H
)
........................................................................................................................................................... 26
6.9 I
DLE
I
MMEDIATE
(95
H OR
E1
H
)
........................................................................................................................................... 26
6.10 M
EDIA
L
OCK
/M
EDIA
U
NLOCK
(DE
H
/DF
H
)
............................................................................................................................ 26
6.11 NOP (00
H
)
.................................................................................................................................................................... 26
6.12 R
EAD
B
UFFER
(E4
H
)
........................................................................................................................................................ 27
6.13 R
EAD
DMA (C8
H
)
........................................................................................................................................................... 27
6.14 R
EAD
DMA E
XT
(25
H
) 48
BIT
LBA
..................................................................................................................................... 27
6.15 R
EAD
FPDMA Q
UEUED
(60
H
) (
IF
NCQ
FEATURE SET SUPPORTED
)
............................................................................................ 28
6.16 R
EAD
M
ULTIPLE
(C4
H
)
..................................................................................................................................................... 28
6.17 R
EAD
M
ULTIPLE
E
XT
(29
H
) 48
BIT
LBA
................................................................................................................................ 29
6.18 R
EAD
N
ATIVE MAX ADDRESS
(F8
H
)
..................................................................................................................................... 30
6.19 R
EAD
N
ATIVE MAX ADDRESS
E
XT
(27
H
)
................................................................................................................................ 30
6.20 R
EAD
S
ECTOR
(
S
) (20
H
)
.................................................................................................................................................... 31
6.21 R
EAD
S
ECTORS
E
XT
(24
H
) 48
BIT
LBA
.................................................................................................................................. 31
6.22 R
EAD
V
ERIFY
S
ECTOR
(
S
) (40
H OR
41
H
)
............................................................................................................................... 31
6.23 R
EAD
V
ERIFY
E
XT
(42
H
) 48
BIT
LBA
................................................................................................................................... 32
6.24 R
ECALIBRATE
(1X
H
)
.......................................................................................................................................................... 32
6.25 S
ECURITY
D
ISABLE
P
ASSWORD
(F6
H
)
.................................................................................................................................. 32
6.26 S
ECURITY
E
RASE
P
REPARE
(F3
H
)
........................................................................................................................................ 33
6.27 S
ECURITY
E
RASE
U
NIT
(F4
H
)
.............................................................................................................................................. 33
6.28 S
ECURITY
F
REEZE
L
OCK
(F5
H
)
............................................................................................................................................ 33
6.29 S
ECURITY
S
ET
P
ASSWORD
(F1
H
)
.......................................................................................................................................... 34
6.30 S
ECURITY
U
NLOCK
(F2
H
)
................................................................................................................................................... 34
6.31 S
EEK
(7X
H
)
..................................................................................................................................................................... 35
6.32 S
ET
F
EATURES
(EF
H
)
........................................................................................................................................................ 35
6.33 S
ET MAX ADDRESS
(F9
H
)
.................................................................................................................................................. 37
6.34 S
ET MAX ADDRESS
E
XT
(37
H
) 48
BIT
LBA
............................................................................................................................. 38
6.35 S
ET
M
ULTIPLE
M
ODE
(C6
H
)
.............................................................................................................................................. 38
Swissbit AG
Industriestrasse 4
CH-9552 Bronschhofen
Switzerland
Swissbit reserves the right to change products or specifications without notice.
www.swissbit.com
industrial@swissbit.com
Revision: 1.21
F-240_data_sheet_CA-HxBV_Rev121.doc
Page 3 of 60
6.36 S
ET
S
LEEP
M
ODE
(E6
H OR
99
H
)
....................................................................................................................................... 39
6.37 S.M.A.R.T. (B0
H
)
........................................................................................................................................................ 39
6.38 S
TANDBY
(96
H OR
E2)
.................................................................................................................................................... 39
6.39 S
TANDBY
I
MMEDIATE
(94
H OR
E0
H
)
.................................................................................................................................. 40
6.40 T
RANSLATE
S
ECTOR
(87
H
)
................................................................................................................................................. 40
6.41 W
RITE
B
UFFER
(E8
H
)
...................................................................................................................................................... 40
6.42 W
RITE
DMA (CA
H
, CB
H
)
................................................................................................................................................. 40
6.43 W
RITE
DMA E
XT
(35
H
) 48
BIT
LBA
................................................................................................................................... 41
6.44 W
RITE
FPDMA Q
UEUED
(61
H
) (
IF
NCQ
FEATURE SET SUPPORTED
)
........................................................................................... 41
6.45 W
RITE
M
ULTIPLE
C
OMMAND
(C5
H
)
.................................................................................................................................... 42
6.46 W
RITE
M
ULTIPLE
E
XT
(39
H
) 48
BIT
LBA
............................................................................................................................. 42
6.47 W
RITE
S
ECTOR
(
S
) (30
H
)
................................................................................................................................................... 43
6.48 W
RITE
S
ECTOR
(
S
) E
XT
(34
H
) 48
BIT
LBA
............................................................................................................................ 43
6.49 W
RITE
V
ERIFY
(3C
H
)
....................................................................................................................................................... 44
7 S.M.A.R.T FUNCTIONALITY
...................................................................................................................................................... 45
7.1 S.M.A.R.T. E
NABLE
/ D
ISABLE OPERATIONS
........................................................................................................................... 45
7.2 S.M.A.R.T. E
NABLE
/ D
ISABLE
A
TTRIBUTE
A
UTOSAVE
.............................................................................................................. 45
7.3 S.M.A.R.T. R
EAD DATA
..................................................................................................................................................... 45
7.4 S.M.A.R.T. R
EAD
A
TTRIBUTE
T
HRESHOLDS
............................................................................................................................ 50
7.5 S.M.A.R.T. R
ETURN
S
TATUS
............................................................................................................................................... 51
8 PACKAGE MECHANICAL
........................................................................................................................................................... 52
9
DECLARATION OF CONFORMITY
........................................................................................................................................ 54
10 ROHS AND WEEE UPDATE FROM SWISSBIT
........................................................................................................................... 55
11 PART NUMBER DECODER
........................................................................................................................................................ 57
11.1 M
ANUFACTURER
................................................................................................................................................................ 57
11.2 M
EMORY
T
YPE
.................................................................................................................................................................. 57
11.3 P
RODUCT
T
YPE
.................................................................................................................................................................. 57
11.4 D
ENSITY
.......................................................................................................................................................................... 57
11.5 P
LATFORM
....................................................................................................................................................................... 57
11.6 P
RODUCT
G
ENERATION
....................................................................................................................................................... 57
11.7 M
EMORY
O
RGANIZATION
..................................................................................................................................................... 57
11.8 T
ECHNOLOGY
.................................................................................................................................................................... 57
11.9 N
UMBER OF
F
LASH
C
HIP
.................................................................................................................................................... 57
11.10 F
LASH
C
ODE
................................................................................................................................................................... 57
11.11 T
EMP
. O
PTION
................................................................................................................................................................. 58
11.12 DIE C
LASSIFICATION
.......................................................................................................................................................... 58
11.13 PIN M
ODE
..................................................................................................................................................................... 58
11.14 D
RIVE CONFIGURATION
XYZ
............................................................................................................................................... 58
11.15 O
PTION
.......................................................................................................................................................................... 58
12 SWISSBIT CFAST MARKING SPECIFICATION
............................................................................................................................. 59
12.1 T
OP VIEW
......................................................................................................................................................................... 59
12.2 B
OTTOM VIEW
.................................................................................................................................................................. 59
REVISION HISTORY
...................................................................................................................................................................... 60
Swissbit AG
Industriestrasse 4
CH-9552 Bronschhofen
Switzerland
Swissbit reserves the right to change products or specifications without notice.
www.swissbit.com
industrial@swissbit.com
Revision: 1.21
F-240_data_sheet_CA-HxBV_Rev121.doc
Page 4 of 60
3 Order Information
3.1 Available Standard part numbers
FIX / SATA II/ UDMA6, MDMA2, PIO4
Density
Part Number
F-240 Series CFast Card
2GB
SFCA2048HgBV4TO-t-MS-2y6-STD
4GB
SFCA4096HgBV4TO-t-MS-2y6-STD
8GB
SFCA8192HgBV4TO-t-DT-2y6-STD
16GB
SFCA16GBHgBV4TO-t-QT-2y6-STD
32GB
SFCA32GBHgBV4TO-t-QT-2y6-STD
64GB
SFCA64GBHgBV4TO-t-NU-2y6-STD
Table 1: Standard temperature product list
g= depends on product generation
t= Temperature “C” commercial (0°c – +70°C) “I” industrial (-40°C – +85°C)
y= depends on firmware generation
3.2 Offered OEM options
Customer specified drive size and drive geometry (C/H/S – cylinder/head/sector)
Customer specified drive ID (Strings)
Preload service (also drive images with any file system)
…
Swissbit AG
Industriestrasse 4
CH-9552 Bronschhofen
Switzerland
Swissbit reserves the right to change products or specifications without notice.
www.swissbit.com
industrial@swissbit.com
Revision: 1.21
F-240_data_sheet_CA-HxBV_Rev121.doc
Page 5 of 60
京公网安备 11010802033920号
EEWORLD
